Product ID:INSCO CLEANER SOLVENT SF
MSDS Date:02/05/1998
FSC:6850
NIIN:00-538-0929
Status Code:A
MSDS Number: CJLNP

ASHLAND CHEMICAL CO DIV OF ASHLAND OIL INC

3849 FISHER RD
COLUMBUS, OH 43216
US

Emergency Phone: 800-274-5263

Info Phone: 800-274-5263 614-798-3333

Cage: 7L600

CHEMICAL SPECIALISTS AND DEVELOPMENT INC

687 CONROE, TX 77305 US

Telephone: 409-756-1065

Cage: 4N760

ALIPHATIC PETROLEUM DISTILLATES

CAS: 64742-89-8

ETHYL ACETATE (CERCLA)

CAS: 141-78-6

RTECS: AH5425000

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM; 9596

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

METHYL ETHYL KETONE (2-BUTANONE) (MEK) (SARA 313) (CERCLA)

CAS: 78-93-3

RTECS: EL6475000

OSHA PEL 200 PPM

ACGIH TLV: 200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

TOLUENE (SARA 313) (CERCLA)

CAS: 108-88-3

RTECS: XS5250000

OSHA PEL 100 PPM

ACGIH TLV: S, 50 PPM

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ISOPROPYL ALCOHOL (SARA 313)

CAS: 67-63-0

RTECS: NT8050000

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:CARDIAC SENSITIZATION,
KIDNEY DAMAGE. ACUTE - EXPOSURE CAN CAUSE EYE IRRITATION, TEARING
AND SWELLING. SKIN CONTACT CAN CAUSE IRRITATION. PROLONGED OR
REPEATED EXPOSURE MAY DRY SKIN. SKI N ABSORBTION IS POSSIBLE.
SWALLOWING LARGE AMOUNTS MAY BE HARMFUL. THIS MATERIAL CAN ENTER
LUNGS DURING SWALLOWING OR VOMITING CAUSING LUNG INFLAMMATION
AND/OR DAMAGE. INHALATION OF HIGH CONCENTRATION S MAY CAUSE
RESPIRATORY TRACT IRRITATION, CNS EFFECTS CHARACTERIZED BY
DIZZINESS, HEADACHE, BREATHING DIFFICULTY, UNCONSCIOUSNESS. CHRONIC
- MAY CAUSE CARDIAC SENSITIZATION, KIDNEY DAMAGE, BRAIN AND N
ERVOUS SYSTEM DAMAGE.
Explanation of Carcinogenicity:BASED ON AVAILABLE INFORMATION, THIS
MATERIAL CANNOT BE CLASSIFIED WITH REGARD TO CARCINOGENICITY. THIS
MATERIAL IS NOT LISTED AS A CARCINOGEN BY IARC, NTP OR OSHA.
Effects of Overexposure:STINGING, TEARING, REDNESS, AND SWELLING OF
EYES; RESNESS, BURNING, DRYING AND CRACKING OF SKIN; METALLIC
TASTE, GASTROINTESTINAL IRRITATION (NAUSEA, VOMITING, DIARRHEA),
IRRITATION (NOSE, THROAT, RES PIRATROY TRACT), DIZZINESS,
DROWSINESS,WEAKNESS, FATIGUE, NAUSEA, HEADACHE, UNCONSCIOUSNESS,
EXCITATION, MUSCLE WEAKNESS, LOW BLOOD PRESSURE, MILD REVERSIBLE
LIVER EFFECTS, EFFECTS ON HEART RATE, RESP IRATORY DEPRESSION,
IMPAIRED COORDINATION, CONFUSION, PULMONARY EDEMA, KIDNEY DAMAGE,
COMA, AND DEATH.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING SKIN
DISORDERS, EYE PROBLEMS OR IMPAIRED CENTRAL NERVOUS SYSTEM, HEART,
LIVER, KIDNEY OR RESPIRATORY FUNCTION MAY BE MORE SUSCEPTIBLE TO
THE EFFECTS OF THIS PRODUCT.

First Aid:INHALED: MOVE TO FRESH AIR. IF BREATHING IS DIFFICULT,
PROVIDE OXYGEN. KEEP PERSON WARM AND QUIET SEEK IMMEDIATE MEDICAL
AID. EYES: IMMEDIATELY MOVE TO FRESH AIR. FLUSH GENTLY WITH WATER
FOR AT LEAS T 15 MINUTES WHILE HOLDING EYELIDS APART. SEEK
IMMEDIATE MEDICAL AID. SKIN: REMOVE CONTAMINATED CLOTHING. FLUSH
EXPOSED AREA WITH LARGE AMOUNT OF WATER. SWALLOWING: IF INDIVIDUAL
IS DROWSY OR UNCONSCI OUS, PLACE ON LEFT SIDE WITH THE HEAD DOWN.
IF POSSIBLE, DO NOT LEAVE INDIVIDUALUNATTENDED. SKIN: REMOVE
CONTAMINATED CLOTHES. FLUSH EXPOSED AREA WITH LARGE AMOUNTS OF
WATER. SEEK IMMEDIATE MEDICAL AI D.

Flash Point Method:TCC
Flash Point:=-12.2C, 10.F

Lower Limits:0.9
Upper Limits:12
Extinguishing Media:REGULAR FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR A SELF-CONTAINED BREATHING APPARATUS WITH
A FULL FACEPIECE OPERATED IN THE POSITIVE PRESSURE DEMAND MODE WITH
AN APPROPRIATE TURN-OUT GEAR AND CHEMICAL RESISSTANT PROTECTIVE
EQUIPMENT.
Unusual Fire/Explosion Hazard:MATERIAL IS HIGHLY VOLATILE AND READILY
GIVES OFF VAPORS WHICH MAY TRAVEL ALONG THE GROUND OR BE MOVED BY
VENTILATION AND IGNITED BY PILOT LIGHTS, OTHER FLAMES, SPARKS,
HEATERS, SMOKING, ELECTRIC MOTO RS, STATIC DISCHARGE, OR OTHER
IGNITIONSOURCES @ LOCATIONS DISTANT FROM MATERIAL HANDLING POINT.

Spill Release Procedures:REMOVE IGNITION SOURCES. CONTAIN LARGE SPILLS
WITH DIKES AND PUMP INTO APPROPRIATE CONTAINERS FOR DISPOSAL.
ABSORB REMAINING MATERIAL/SMALL SPILLS WITH NON-FLAMMABLE MATERIAL
SUCH AS SAND, CLAY, EARTH , FLOOR ABSORBENT OR VERMICULITE. PLACEIN
A CONTAINER FOR DISPOSAL. CLEAN AREA THOROUGHLY TO REMOVE RESIDUAL
CONTAMINATION. PREVENT RUNOFF FROM ENTERING SEWERS/WATERWAYS.
REPORT SPILLS IF REQUIRED.

Handling and Storage Precautions:CONTAINERS OF THIS MATERIAL MAY BE
HAZARDOUS WHEN EMPTIED. SINCE EMPTIED CONTAINERS RETAIN PRODUCT
RESIDUE, ALL HAZARD PRECAUTIONS GIVEN IN THIS DATA SHEET MUST BE
OBSERVED. ALL FIVE-GALLON PAILS AND LARGER METAL CONTAINERS,
INCLUDING TANKCARS AND TANK TRUCKS SHOULD BE GROUNDED AND/OR
BONDED.
Other Precautions:SMALL SPILL-ABSORB LIQUID ON VERMICULITE, FLOOR
ABSORBENT OR OTHER ABSORBENT MATERIAL.

Respiratory Protection:IF WORKPLACE EXPOSURE LIMIT OF PRODUCT OR ANY
COMPONENT IS EXCEEDED, A NIOSH/MSHA APPROVED AIR SUPPLIED
RESPIRATOR IS ADVISED IN ABSENCE OF PROPER ENVIRONMENTAL CONTROL.
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST, EXPLOSION FREE) VENTILATION TO MAINTAIN EXPOSURE BELOW
TLV(S).
Protective Gloves:NITRILE, RUBBER
Eye Protection:CHEMICAL SPLASH GOGGLES IN COMPLIANCE WITH OSHA
REGULATIONS
Other Protective Equipment:TO PREVENT REPEATED OR PROLONGED SKIN
CONTACT, WEAR IMPERVIOUS CLOTHING AND BOOTS. EYE BATH, WASHING
FACILITY, EMERGENCY SHOWER
Work Hygienic Practices:OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. WASH AFTER HANDLING AND BEFORE EATING,
DRINKING OR SMOKING.
Supplemental Safety and Health
WARNING! SUDDEN RELEASE OF HOT ORGANIC CHEMICAL VAPORS OR MISTS FROM
PROCESS EQUIPMENT OPERATING AT ELEVATED TEMPERATURES AND PRESSURES
MAY RESULT IN IGNITION WITHOUT THE PRESENCE OF OBVIOUS IGNITION
SOURCES. USAGE AT ELEVATED TEMPERATURESREQUIRES REEVALUATION TO
MAINTAIN SAFE OPERATION.

HCC:F2
Boiling Pt:=75.6C, 168.F
Vapor Pres:76 MMHG @ 68F
Vapor Density:>1.000
Spec Gravity:0.805
pH:N/APPLICABLE
VOC Grams/Liter:5.76
Evaporation Rate & Reference:SLOWER THAN ETHYL ETHER
Appearance and Odor:LIQUID HOMOGENEOUS SOLUTION. NO DATA ON COLOR AND
ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
ACETALDEHYDE, ACIDS, CHLORINE, ETHYLENE OXIDE ISOCYANATES, STRONG
OXIDIZING AGENTS.
Stability Condition to Avoid:DO NOT USE WITH ALUMINUM EQUIPMENT AT
TEMPERATURES ABOVE 120 F.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE, AND
VARIOUS HYDROCARBONS.
Conditions to Avoid Polymerization:PRODUCT WILL NOT UNDERGO HAZARDOUS
POLYMERIZATION.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL LAWS AND REGULATIONS.

Toxicological Information:NO DATA

Ecological:NO DATA

Transport Information:DOT INFORMATION: COMPOUNDS, CLEANING, LIQUIDS, 3,
NA1993, II. CONTAINER/MODE: 55 GAL DRUM/TRUCK PACKAGE. NOS
COMPONENTS: ETHYL ACETATE, ALIPHATIC PETROLEUM DISTILLATES.

SARA Title III Information:METHYL ETHYL KETONE, XYLENE, AND TOLUENE ARE
SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313 OF TITLE III
OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT (SARA) OF 1986
AND 40 CFR PART 372.65
Federal Regulatory Information:CERCLA RQ: ETHYL ACETATE = 5000 LBS; MEK
= 5000 LBS, TOLUENE = 1000 LBS AND XYLENE = 100 LBS AND ARE LISTED
ON TSCA LIST.
State Regulatory Information:CALIFORNIA PROPOSITION 65: THE FOLLOWING
STATEMENT IS MADE IN ORDER TO COMPLY WITH THE CALIFORNIA STATE SAFE
DRINKING WATER AND TOXIC ENFORCEMENT ACT OF 1986: THIS PRODUCT
CONTAINS BENZENE, A SUBSTANC E KNOWN TO THE STATE OF CALIFORNIA TO
CAUSE CANCER. THIS PRODUCT CONTAINS TOLUENE, A STUBTANCE KNOWN TO
THE STATE OF CALIFORNIA TO CAUSE REPRODUCTIVE HARM. NEW JERSEY RTK
LABEL INFORMATION.: NAPHTHA S OLVENT, ETHYL ACETATE, METHYL ETHYL
KETONE, TOLUENE, ISOPROPANOL, XYLENE. PENNSYLVANIA RTK LABEL IN
FORMATION: ACETIC ACID ETHYL ESTER, 2-BUTANONE, BENZENE,METHYL-,
2-PROPANOL, BENZENE, DIMETHYL-.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.